Your IP address and browser information will be recorded as proof of this acknowledgement. This data is retained for 12 months.
The Ford PowerShift dual clutch transmission shudders on pull-away and hesitates during low-speed manoeuvring. This fault affected millions of Ford Focus and Fiesta models worldwide and led to multiple class action lawsuits. A TCU software update provides partial improvement but does not eliminate the fundamental design issue with the wet clutch design at low speeds. Many owners required repeated clutch replacements under warranty.
Based on 312 driver confirmations
After two clutch replacements in 3 years I gave up. Part-exchanged for a manual gearbox Focus. No more shudder, no more anxiety about whether it'll get worse. The PowerShift is a fundamentally flawed design for city driving. If you're buying a Focus, get the manual.
Parts replaced: N/A — sold vehicle
Had the clutch pack replaced under extended warranty. Shudder went away completely. Came back 18 months later. This is a design flaw not a wear issue — the dry clutch design is not suited to stop-start traffic. Ford eventually offered buybacks on some cars. If still in warranty push for that.
Parts replaced: Dual clutch pack (DCT)
Shudder on light throttle from low speed. Ford dealer did a TCM (transmission control module) software update as part of the class action settlement. Shudder noticeably reduced though not 100% gone. Better than it was. Check if your VIN is covered by the Ford settlement.
Parts replaced: Nothing — software update
Your real-world fix helps thousands of drivers worldwide. Takes 2 minutes.